+86 0371 8654 9132

ceramic waste using concrete

(PDF) use of ceramic waste in concrete: a review

So, what is done that the OPC cement is replaced with the waste of ceramic powder consequently in various stages: 0%, 15%, 20%, 25%, 30%, and 35% using grade M-20 weight of concrete.

Read More
Use of ceramic wastes as aggregates in concrete

The use of ceramic waste, originated from construction sites and industries, as fine and coarse aggregate in concrete presents an effective and sustainable endeavor to environmental problems through the reduction in the degradation of natural resources caused by extraction of natural aggregates and decrease in dumping volume as well ...

Read More
(PDF) Ceramic waste in concrete-A Review - ResearchGate

In this research study the (OPC) cement has been replaced by ceramic waste in the range of 0%, 10%, 20%, 30% 40%, 50% by weight for M-30 grade concrete. Concrete samples tested and compared in ...

Read More
Use of Ceramic Waste Powder in Cement Concrete

2015-6-10  Therefore using of ceramic waste powder in concrete would benefit in many ways in saving energy protecting the environment. The cost of deposition of ceramic waste in landfills will be saved.Raw materials and natural resources will be replaced. Which indirectly

Read More
Concrete with ceramic waste aggregate - ScienceDirect

2005-10-1  Six ceramic waste coarse aggregate concrete mixes were designed by the volumetric method with different water–cement ratios (0.35, 0.40, 0.45, 0.50, 0.55 and 0.60). Similarly, six more conventional concrete mixes were designed with crushed stone coarse aggregate. The volume of individual ingredients was the same in both the ceramic waste ...

Read More
A Review Paper on Utilisation of Ceramic Waste in

2016-9-9  Ceramic waste concrete (CWC) will be made with these tiles at 0%, 15%, 20%, 25% and 30%. M. 20. grade concrete will be adopted; a constant water cement ratio of 0.48 will be maintained for all the concrete mixes. The characteristics properties of concrete such as workability for fresh concrete, also

Read More
The Use of Ceramic Tile Waste as Aggregate in Concrete

2017-12-18  using ceramic tile waste as aggregate in concrete. The experi-mental program was designed to achieve the following objec-tives: 1) Determining the physical and mechanical characterization of recycled ceramic tile waste aggregate. 2) Studyingthe effect of using recycled ceramic tile waste

Read More
Ceramic Waste : Effective Replacement Of Cement For ...

2017-2-8  The evaluation of ceramic waste for use as a replacement of cement material begins with the concrete testing. Concrete contains cement, water, fineaggregate, coarse aggregate and grit. With the control concrete, i.e. 10%, 20%, 30%, 40%, and 50% of the cement is replaced with ceramic waste,the data from the ceramic waste is

Read More
Experimental investigation of ceramic waste concrete

2017-10-11  the ceramic waste concrete casts and curing with magnetic water and normal water is compared with data from a standard concrete. 20 cube samples were cast for each type on the mould of size 150*150*150 mm. After about 24 hours the specimens were demoulded and water curing was continued till the respective specimens were tested after 7, ...

Read More
Experimental Investigation Of Using Ceramic Waste As A ...

2015-6-3  Experimental, Investigation, Using Ceramic Waste, Coarse Aggregate, Light Weight Concrete 1 INTRODUCTION Lightweight aggregates can fill many roles that will make human activity more environmentally responsible. The green house gas emission associated with both the processing of the raw material and from the fuel burned to produce the

Read More
(PDF) use of ceramic waste in concrete: a review

So, what is done that the OPC cement is replaced with the waste of ceramic powder consequently in various stages: 0%, 15%, 20%, 25%, 30%, and 35% using grade M-20 weight of concrete.

Read More
A Review Paper on Utilisation of Ceramic Waste in

2016-9-9  Ceramic waste concrete (CWC) will be made with these tiles at 0%, 15%, 20%, 25% and 30%. M. 20. grade concrete will be adopted; a constant water cement ratio of 0.48 will be maintained for all the concrete mixes. The characteristics properties of concrete such as workability for fresh concrete, also

Read More
Use of Ceramic Waste Powder in Cement Concrete

2015-6-10  Therefore using of ceramic waste powder in concrete would benefit in many ways in saving energy protecting the environment. The cost of deposition of ceramic waste in landfills will be saved.Raw materials and natural resources will be replaced. Which indirectly

Read More
The Use of Ceramic Tile Waste as Aggregate in Concrete

2017-12-18  using ceramic tile waste as aggregate in concrete. The experi-mental program was designed to achieve the following objec-tives: 1) Determining the physical and mechanical characterization of recycled ceramic tile waste aggregate. 2) Studyingthe effect of using recycled ceramic tile waste

Read More
Reuse of Ceramic Waste as Aggregate in Concrete

2016-10-10  Ceramic waste is durable, hard and highly resistant to Biological, Chemical and Physical degradation forces. Ceramic tile aggregate are hard having considered value of specific gravity, rough surface on one side and smooth on other side, are lighter in weight than normal stone aggregates. Using ceramic tiles as aggregate in concrete

Read More
Utilization of ceramic waste by using it as special ...

2019-1-1  Utilization of ceramic waste by using it as special concrete aggregate. P Ogrodnik 1 and J Szulej 2. Published under licence by IOP Publishing Ltd IOP Conference Series: Earth and Environmental Science, Volume 214, International Conference on the Sustainable Energy and Environmental Development 14–17 November 2017, Krakow, Poland Citation P Ogrodnik and J Szulej 2019 IOP

Read More
Experimental Investigation Of Using Ceramic Waste As A ...

2015-6-3  Experimental, Investigation, Using Ceramic Waste, Coarse Aggregate, Light Weight Concrete 1 INTRODUCTION Lightweight aggregates can fill many roles that will make human activity more environmentally responsible. The green house gas emission associated with both the processing of the raw material and from the fuel burned to produce the

Read More
Experimental Study on the Behaviour of Ceramic Waste

2020-12-7  workability of concrete made using ceramic waste decreased with increase in replacement level. Table.5: Slump value of normal sand and ceramic waste concrete Figure.3: Slump value of normal sand and ceramic waste concrete The Compression Strength test The compressive test was conducted in universal testing machine (UTM) in a capacity of 40 tonnewas

Read More
Analysis of Mix Design of Concrete Using Ceramic Waste

Analysis of Mix Design of Concrete Using Ceramic Waste and Rice Husk Ash M Faizan Dhrolwala1, Kaushik Kanani2, Divyesh Patel3 and Dharti Soni4 1,2,3 Student, Civil Engineering Dept., Vadodara Institute of Engineering. 4Assistant Professor, Civil Engineering Dept., Vadodara Institute of Engineering. [email protected], [email protected], [email protected],

Read More
Recycling ceramic waste powder and its usage as an ...

2020-10-13  morphology and mineralogical configuration of ceramic waste material were determined using X-ray diffraction (XRD) method. In the second phase, CWP was used as SCM with altered dosages replacing cement material in mixtures. At that phase, the effect of CWP as SCM on the properties of fresh concrete

Read More
(PDF) use of ceramic waste in concrete: a review

So, what is done that the OPC cement is replaced with the waste of ceramic powder consequently in various stages: 0%, 15%, 20%, 25%, 30%, and 35% using grade M-20 weight of concrete.

Read More
Use of ceramic wastes as aggregates in concrete

The use of ceramic waste, originated from construction sites and industries, as fine and coarse aggregate in concrete presents an effective and sustainable endeavor to environmental problems through the reduction in the degradation of natural resources caused by extraction of natural aggregates and decrease in dumping volume as well ...

Read More
Ceramic Waste : Effective Replacement Of Cement For ...

2017-2-8  The evaluation of ceramic waste for use as a replacement of cement material begins with the concrete testing. Concrete contains cement, water, fineaggregate, coarse aggregate and grit. With the control concrete, i.e. 10%, 20%, 30%, 40%, and 50% of the cement is replaced with ceramic waste,the data from the ceramic waste is

Read More
Concrete with ceramic waste aggregate - ScienceDirect

2005-10-1  Six ceramic waste coarse aggregate concrete mixes were designed by the volumetric method with different water–cement ratios (0.35, 0.40, 0.45, 0.50, 0.55 and 0.60). Similarly, six more conventional concrete mixes were designed with crushed stone coarse aggregate. The volume of individual ingredients was the same in both the ceramic waste ...

Read More
(PDF) Ceramic waste in concrete-A Review - ResearchGate

In this research study the (OPC) cement has been replaced by ceramic waste in the range of 0%, 10%, 20%, 30% 40%, 50% by weight for M-30 grade concrete. Concrete samples tested and compared in ...

Read More
(PDF) Concrete with ceramic waste aggregate

Use of hazardous industrial wastes in concrete-making will lead to greener environment. In ceramic industry about 30% production goes as waste, which is not recycled at present.

Read More
Experimental study on concrete using waste ceramic as ...

2021-1-1  2021-1-1  A new concrete test has been conducted to determine the workability of concrete. The slump cone test was conducted out in concrete batches for various percentages of waste ceramics, as shown in Table 7. The water-cement ratio improves the workability of the concrete, with the addition of ceramic waste materials as fine aggregate.

Read More
Reusing Ceramic Wastes in Concrete Request PDF

Ceramic waste (CW) was utilized in different ratios of 50% and 100% replacing the fine aggregate weight. Plastic fibers were added in ratios of 1.5% and 2.5% by weight of concrete. The engineering ...

Read More
Partial Replacement of Cement in Concrete using

2019-12-23  recycling ceramic waste can be used in different construction application. Researches used ceramic waste to generate green concrete by using 20% replacement of natural aggregate. It can be shown that the concrete produce from ceramic waste is good workable and achieve characteristic strength [9, 10, 11, 12].

Read More
Characterization of ceramic waste aggregate concrete ...

2018-12-1  Thus, the current study focuses on the mechanical characterization of waste ceramic wall and floor tiles aggregate concrete. Ceramic wastes sourced from construction and demolition wastes were separated from other debris and crushed using a quarry metal hammer. Ceramic tiles were sieved into fine and coarse aggregates in line with standards.

Read More